Welcome to

Isuzu Marine Engine 42hp with PRM 150 D2 Gearbox

£3,750.00 inc. tax


Isuzu 42hp with PRM 150D2 Hydraulic Gearbox

Recently rebuilt, this is a good quality engine with no previous faults from a shared-boat ownership origin. The engine  has been rebuilt to the spec below. This is a great quality Isuzu and any test is welcome.

 A brand new drive plate has been fitted prior to the gearbox being fitted. 

The engine is set up for keel cooling and is ideally suited to a narrowboat up to around 65ft length - an ideal upgrade or would suit a DIY self-fitter. The engine is supplied with twin alternators. 

  • Reconditioned cylinder head 
  • Chemical clean 
  • Pressure test 
  • Valve guides inspected 
  • Valves inspected
  • Injectors serviced and new OEM nozzles  
  • Fuel pumps tested, rebuilt and new seals
  • New injector seals / heat shields 
  • Rails cleaned (spill and fuel pumps) 
  • New rail seals 
  • Heater plugs tested
  • New fuel lines and clips where required
  • Valve stem seals replaced 
  • Valves reground 
  • Head skimmed (see photos)
  • New head gasket 
  • New stretch bolts 
  • Block strip and chemical clean 
  • Crank inspected - polished and tested for straightness
  • New crank seals, front and back 
  • Crank bearings replaced
  • Conrod bearings replaced 
  • Thrust bearings replaced
  • Bores measured with dial bore gauge – pass within Isuzu specified limits 
  • Piston rings replaced
  • Sump plug washers replaced 
  • Sump gasket replaced 
  • New U-shin OEM lift pump
  • Stop solenoid tested
  • Alternators tested
  • x 1 reconditioned starter alternator
  • x 1 new 110amp leisure / auxiliary alternator
  • Starter motor tested      
  • New wiring loom fitted 
  • Pump (coolant) removed, inspected 
  • New gasket 
  • New hoses and clips where required
  • Header tank removed, inspected - new exhaust gasket
  • New header cap and new neck seal 
  • Repaint in blue engine enamel 
  • Mounts replaced
  • Supplied with control panel
  • Throttle / gear cable clamps replaced 
  • New alternator belts 
  • Valve clearances checked / adjusted 
  • Operating test 
  • New oil, new oil fuel and air filters
  • Gearbox operation test
  • Gearbox oil changed  
Product Code: eng1
Units in Stock:
Product Condition: Refurbished
No Reviews Posted Yet - be the first!
(write review)
Product Added to your Cart

-------- OR --------